Communicate with Supplier? Supplier
Simba Lee Mr. Simba Lee
What can I do for you?
Contact Supplier

Shenzhen Toyocool Refrigeration Equipment Co.,Ltd.

Home > News > Some Industrial Air/Water cooled chiller FAQ,Solve your doubts.

Some Industrial Air/Water cooled chiller FAQ,Solve your doubts.

2020-11-18
Q : How to anti-freeze for a laser system Water chiller?
A : Three tips to guard your chiller through winter.
"Working 24 hours"
Run the chiller for 24 hours per day and make sure the water under recirculation status.
"Empty the water"
Empty the water inside the laser, laser head and chiller after done with using.
"Add antifreeze"
Add antifreeze into the water tank of chiller. S&A recommends the antifreeze which is exclusive used for automobile.
Note: all kinds of antifreeze contain certain corrosive property, not to be used for long period. Please use clean pipes with deionized water or distilled water after winter, and refill deionized water or distilled water as the cooling water.

Warm Note: because antifreeze contains certain corrosive property, please dilute it strictly according to usage note before adding into cooling water.


Antifreeze Tips
Antifreeze usually uses alcohols and water as base with high boiling point, freezing point, specific heat and conductivity for anti-corrosion, anti-incrustant and rust protection.
Three important principles of chillers antifreeze need to aware during usage.
1. The lower concentration the better. As most antifreeze with corrosiveproperty,the concentration will be the lower the better under condition of antifreeze requirement meet.
2. The shorter usage period the better.Antifreeze will deteriorate after long time use, the corrosive will stronger and viscosity will change. So need to replaceregular, recommend to replacing after 12 months usage.Use pure water at summer, and replace new antifreeze at winter.

3. Don`t mix up. Better use the same brand antifreeze. Even the main components are the same for different brandsantifreeze, the additive formulas are different, so don`t suggest combine different brands antifreeze, in case chemistry reaction, sediment or air bubble happen.


Q : Chiller turned on but unelectrified


A : Failure Cause:
A. Power cord is not plugged in place
Approach: Check and ensure the power interface and the power plug is plugged in place and in good contact.
B. Fuse burnt-out
Approach: Replace the protective tube in the power socket on the back of chiller.
Q : Flow Alarm (controller displays E6)use a water pipe directly connect to the water outlet and inlet but still without water flowing

A : Failure Cause:
Water level in the storage water tank is too low
Approach: Check the water level gauge display, add water until the level shown in the green area; And check whether water circulation pipe leaks.


Q : Flow Alarm occurs while running with other equipment (controller displays E6),but there is water flowing and no alarm whten use a water pipe directly connected to the chiller water outlet and inlet.

A : Failure Cause:
Water circulation pipes are blocked or a pipe bending deformation.
Approach:
Check water circulation pipe


Q : Ultra-high temperature alarm


A : Failure Cause:
A. Blocked dust gauze, bad thermolysis
Approach: Unpick and wash the dust gauze regularly
B. Poor ventilation for air outlet and inlet
Approach: To ensure a smooth ventilation for air outlet and inlet
C. Voltage is extremely low or astable
Approach: To improve the power supply circuit or use a voltage regulator
D. Improper parameter settings on thermostat
Approach: To reset controlling parameters or restore factory settings
E. Switch the power frequently
Approach: To ensure there is sufficient time for refrigeration (more than 5 minuets)
F. Excessive heat load
Approach: Reduce the heat load or use other model with larger cooling capacity

Shenzhen Toyocool Refrigeration Equipment Co.,Ltd.
Business Type:Manufacturer , Trade Company , Distributor/Wholesaler , Service
Product Range:Chilling Equipment , Chemical & Pharmaceutical Machinery , Refrigeration & Heat Exchange Equipment
Products/Service:Water chiller , Cooling machine , Water Cooled Chiller , Air Cooled Chiller , Heat Exchanger , Screw water chiller
Certificate:ISO9001 , CB , CE , CCC , RoHS
Company Address:Building 17,Third Industrial Zone,Longxi Community,Longgang District, Shenzhen, Guangdong, China

Previous: Low temperature water chiller maintenance and care

Next: How the chiller works?----toyocool Air/water chiller

Home

Phone

About Us

Inquiry